KLR Weight Question - Kawasaki KLR 650 Forum
Go Back   Kawasaki KLR 650 Forum > KLR 650 > 1987 to 2007 Wrenching & Mods

1987 to 2007 Wrenching & Mods For maintaining, repair or modifications of Generation 1 KLR's. 2007 and earlier.

Reply
 
Thread Tools Display Modes
  #1  
Old 11-28-2011, 08:58 AM
Bigryamaha Bigryamaha is offline
Flight Officer
 
Join Date: Oct 2011
Location: Louisville, KY
Posts: 67
Default KLR Weight Question

The spec's I find show the dry weight of a 2007 KLR650 at 337lbs. The 2011 shows a wet weight of 432lbs. Assuming fuel, oil, and water at about 40lbs, the newer models would weigh 50+lbs more. Is this correct???? Where is the weight gain?
Reply With Quote
Sponsored Links
Advertisement
 
  #2  
Old 11-28-2011, 09:26 AM
LoneRider LoneRider is offline
Banned
 
Join Date: Jan 2010
Location: Mid-Atlantic
Posts: 765
Default

Discrepancies exist in "official" Kawasaki KLR specifictions; for example, Kawasaki would have you believe Generation 2 ('08 and later) KLR's have SINGLE PISTON rear brake calipers, where I count TWO.

Just to neutralize any errors, you can take your bathroom scales to the garage, place front or rear wheel upon them, shimming the opposite wheel to approximately level orientation, and note weight. Repeat, reversing wheels. Add sums of weight, and . . . you come up pretty close to "ground truth" regarding your bike's weight, regardles of any published numbers.

Generation 2's, I think, are somewhat heavier; not as much as the spcification sheet might suggest, however.
Reply With Quote
  #3  
Old 11-28-2011, 10:03 AM
Spec's Avatar
Spec Spec is offline
Colonel
 
Join Date: Apr 2010
Location: Gateway to Death Valley!
Posts: 1,939
Default

Quote:
Originally Posted by Bigryamaha View Post
The spec's I find show the dry weight of a 2007 KLR650 at 337lbs. The 2011 shows a wet weight of 432lbs. Assuming fuel, oil, and water at about 40lbs, the newer models would weigh 50+lbs more. Is this correct???? Where is the weight gain?

Kawasaki was uh... optomistic about the Gen 1 weight. It weighs about 400 lbs wet (Wiki here).

The Gen 2s are about 25 lbs. heavier by most accounts.

BTW wet weight generally doesn't include much gas in the tank, just all the other fluids. There are no standards for weighting a motorcycle apparently.
__________________
No eye has seen, no ear has heard, no mind has conceived what God has prepared for those who love him. 1 Cor 2:9
Reply With Quote
  #4  
Old 11-28-2011, 05:00 PM
Tom Schmitz's Avatar
Tom Schmitz Tom Schmitz is offline
Pretty in Pink, dunno why
 
Join Date: Feb 2009
Posts: 3,685
Default

I read this somewhere, and it was recent. I'll try to find the cite, but it went something like this...

Prior to the model year 2008 almost all motorcycle manufacturers gave the weights of bikes less "expendables". In some cases that meant without tires, and in almost all cases it ment without oil and gas. The weights of motorcycles pre and post 2008 vary widely due to this.

Apparently, they've all sort of gotten their act together and now pretty much report weights "ready to go".

Like I said, I'll try and find the cite for this.

T
__________________
PPMC # 5

'Why' and 'How' are words so important they cannot be too often used. -Napoleon Bonaparte
Reply With Quote
  #5  
Old 11-28-2011, 05:28 PM
Buildit's Avatar
Buildit Buildit is offline
Colonel
 
Join Date: Oct 2006
Location: London, Ohio
Posts: 1,123
Default

It's all that extra plastic to make the front cowling. Another way to get your real weight is to take it to a fertilizer distributer. Almost every single one around here has a drive on scale that is good to 5 or 10 pounds accurate. I think mine with the IMS tank full was around 440-450 lbs.
__________________
*** KLR650, Tweeting long before your kids thought it was cool.

ADVFilmer videos of trails, reviews and other dual sport related stuff. http://www.youtube.com/user/advfilmer
Reply With Quote
  #6  
Old 11-28-2011, 09:21 PM
Bigryamaha Bigryamaha is offline
Flight Officer
 
Join Date: Oct 2011
Location: Louisville, KY
Posts: 67
Default

Thanks for the input. It's not really a big deal but just couldn't believe that there could be that much difference. I'll be riding my '07 for a while and bought it thinking it might be a little more dirt friendly than the gen2. So far it is a much better rider than I am but am having a blast getting aquainted. Have added bark busters, HT crash bars and skid plate so weight is up a little anyway. Just hoping that Santa knows how fun new farkles are! Still looking for good places to ride in Kentucky.
Reply With Quote
  #7  
Old 11-29-2011, 12:49 AM
Gatecrasher Gatecrasher is offline
Flight Officer
 
Join Date: Oct 2011
Location: Portland, Oregon
Posts: 48
Default

Crash bars and skid plates carry most of the extra weight low in the bike so it should not be a huge difference unless you are picking the bike up from it being on it's side. In which case you will be glad you have both fitted
Reply With Quote
  #8  
Old 03-03-2012, 10:00 AM
Watt-man's Avatar
Watt-man Watt-man is offline
Flight Officer
 
Join Date: Jan 2009
Location: Phoenix, AZ
Posts: 33
Default

A number of people have commented on the supposed 51-pound weight gain from 07 to 08 (as told to us by Kawasaki). I would argue the true weight increase was around 17 pounds. Kawasaki has an accurate weight posted for 08 and newer, but the 07 and earlier number was bogus as you'll find below.
--------------------------------------------
I found what appears to be an accurate weighing of a fully-fueled 2005 and 2008. Since they didn’t use the data to draw all the conclusions I was looking for, I wanted to take that information and provide some BOTTOM LINE numbers for the group. I’ll work this backwards: Answers first, then details if people want to read how it was calculated.

ANSWERS:

* The 2008 gained around 17 pounds from the earlier model.

*** DRY WEIGHT (no fuel, coolant, or oil):
*** 2008: measured 387 pounds. KHI says it’s 386. Essentially dead-on!
*** 2005: measured 370 pounds. KHI says it’s 337. We’ve all argued they’ve been off with that number for a while, what I’m implying today is that they’ve been quoting 33 pounds below actual for a number of years.

***** WET WEIGHT (full fuel, coolant and oil):
***** 2008: measured 428 pounds
***** 2005: measured 411 pounds (I also have weighed my 2004: also got 411 pounds with full fuel)

DETAILS:

The 2008 was essentially weighed twice and indicated 428 pounds each time. This is where the “WET” weight quoted above originated. They also weighed a 2005 model twice, and obtained 409 pounds one time and 413 pounds the other. I’m using the average of those two values, or 411 quoted above in “WET”. The difference between 411 and 428 provides the 17 pound delta between model years.

The difference between "wet" and "dry" is simply 41 pounds. First, we know they really don’t hold 6.1 gallons of fuel, more like 5.7. Since gasoline weighs 6.2 to 6.3 pounds per gallon, that is essentially 35 pounds. Next; 2.5 quarts of oil and 40 ounces of coolant come out very close to 6 pounds. So if there is no fuel, coolant or oil, we lose another 41 pounds. These values are quoted in the “DRY” section above.

Hopefully this will provide some clarity on the subject.
__________________
Watt-man

'04 KLR650, 90,000 Miles
'09 KLX250, 6,000 Miles
... both with Thermo-Bobs, of course!
www.watt-man.com
Ride it like you own it!

Last edited by Watt-man; 03-03-2012 at 10:02 AM.
Reply With Quote
Sponsored Links
Advertisement
 
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
Weight Loss peter650 2008+ KLR650 Wrenching & Mod Questions 36 06-28-2011 11:35 PM
packable weight on a KLR frame? Grim KLR & Other Motorcycle Related Discussion 6 06-09-2010 10:35 PM
O7 weight thumbs 1987 to 2007 Wrenching & Mods 5 04-28-2008 09:13 PM
COCR Heavy Weight Dual Sport 7/29/07 Ohio Buildit Upcoming Tech Days & Group Rides 0 07-20-2007 09:19 PM
Weight reduction dalahare 1987 to 2007 Wrenching & Mods 1 10-21-2006 04:08 AM


All times are GMT -5. The time now is 10:31 AM.



Powered by vBulletin® Copyright ©2000 - 2014, Jelsoft Enterprises Ltd.
Motorcycle News, Videos and Reviews
Honda Grom Forum Harley Davidson Forum Honda 600RR Kawasaki Forum Yamaha R6 Forum Yamaha FZ-09 Forum
1199 Panigale Forum Roadglide Forum Honda CBR1000 Forum Vulcan Forum Yamaha R1 Forum Yamaha R3 Forum
Ducati Monster Forum Harley Forums Honda CBR250R Forum ZX10R Forum Star Raider Forum Yamaha Viking Forum
Suzuki GSXR Forum V-Rod Forums Honda Shadow Forum Kawasaki Motorcycle Forum Star Warrior Forum KTM Duke 390 Forum
SV650 Forum BMW S1000RR Forum Honda Fury Forum Kawasaki Versys Forum Drag Racing Forum Ducati 899 Panigale Forum
Suzuki V-Strom BMW K1600 Triumph Forum Victory Forums Sportbikes BMW NineT Forum
Volusia Forum BMW F800 Forum Triumph 675 Forum MV Agusta Forum HD Street Forum Suzuki GW250 Forum
Yamaha Motorcycles Victory Gunner Forum Honda Vultus Forum HD LiveWire Forum