Kawasaki KLR Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-12 of 13 Results
  1. Other KLR's - 250, 600, Tengai, C Models, KLX...
    I have a 1989 klr 250 that I acquired a few months back and got running but the carb has some broken and striped parts on it so i ordered a cheap replacement that says it fits but the carbs bore and flange are much smaller than what's on the bike and its completely possible that i was sent the...
  2. KLR & Other Motorcycle Related Discussions
    got a 1988 klr250 but it has no plastics and i cant seem to find a new set anyone know where i could find a set
  3. New Member Introductions
    Hi everyone. Well I sold my last bike 35 years ago when dad said if I wanted a car, My beloved CR250 had to go. Well I bought a 95KLR250 (the barbie bike) on a bit of a whim over the winter. I've been going all over it and found a few problems along the way. From a stripped out case for the oil...
  4. Other KLR's - 250, 600, Tengai, C Models, KLX...
    I'm not sure if I'm early or late to this party (or if the party is already over) but I figured I'd slap up whatever success I've had in the hopes it'll help someone else someday. I recently bought my very first KLR, a turquoise and purple 1990 KLR250. She needed help, and one of the most...
  5. KLR & Other Motorcycle Related Discussions
    I only have a KLR250 engine together with the wiring harness. Problem is I have no spark at the end of the coil. Testing done: 1. Pick up coil = resistance is 116 ohms. Ok from Manual. 2. Stator Secondary coil = 0.8 ohms. Good 3. Stator Primary coil = 84 ohms. Not sure they say must be around...
  6. Other KLR's - 250, 600, Tengai, C Models, KLX...
    Just to start this off I am brand new to motorcycles. I can’t seem to find a lot of Info for the KLR250 5’ 9” 175 pound rider I am looking for advice on the following topics: Best Oil and Filter to use in Changes Best Spark Plug Replacement? What fork boots to order? What fork oil to Use...
  7. Other KLR's - 250, 600, Tengai, C Models, KLX...
    Hi All, first time on the forum. I have acquired a KLR250 which is currently completely disassembled. Ive been looking around for a workshop manual but with no luck, Does anyone have one? Thanks Dan
  8. Other KLR's - 250, 600, Tengai, C Models, KLX...
    This is the 56th time the carb has been off, so bear with me. - been chasing an air leak. I have finally narrowed it down to the intake boot from the carb to the case. But with no cracks and a rubber seal intact I can still not get a solid seal. Idles fine, but spray starter fluid at the...
  9. KLR & Other Motorcycle Related Discussions
    I’ve got an 00’ klr 250d and would like to do some adventure touring on it as it is a capable and light off-reader and can keep up on country highways. Are there good options for panniers out there (preferably hard shell and lockable)? or is that overkill and a soft bag is a must? should i get a...
  10. Other KLR's - 250, 600, Tengai, C Models, KLX...
    Hey folks, I have recent acquired a 88 KLR 250 that had been sitting in a shed collecting dust for about 15 years. I have replaced the carb with a brand new one, I have spark, new battery, new oil & coolant. Everything I can think of I have tried with no luck.. Any advice would be greatly...
  11. Other KLR's - 250, 600, Tengai, C Models, KLX...
    Hello All: Longtime owner of a 2001 KLR250 that I've had for years and put thousands of local miles on. I replaced a blown rear shock about five years ago after waiting for a cheap one to come across e-bay. Now the new-to-me shock has blown -it was used and looked a bit past its prime when I...
  12. Other KLR's - 250, 600, Tengai, C Models, KLX...
    Hi Guys: Long time KLR owner with a 2001 KLR250. In a nutshell: my thumb lever choke on the left side of the handlebar lost its' bolt so now the choke lever is just dangling. It's still usable. Can anyone advise the thread/length of the mounting bolt for this? I see complete replacements on Ebay...
1-12 of 13 Results
Top